____________________________________________________________________________________
| Home / Small Engines / Honda Engines / Honda GC160 |
Honda GC160 Troubleshooting
| Engine Model: Honda GC160 |
| Engine Type: 4-cycle 1-cylinder air-cooled gasoline engine |
| Total Displacement: 9.8 cu.in (160 cc) |
| Rated Engine Power: 5 Hp (3.7 kW) at 3600 rpm |
| Carburetor Type: Horizontal, butterfly valve |
____________________________________________________________________________________
| Engine doesn't start or difficult to start |
Empty fuel tank - Add gasoline.
Wrong grade of gasoline - Change fuel.
Water or air in fuel system - Remove air or water from system.
Spark plug wire connection are damaged - Inspect the spark plug wire connection, replace or repair.
Spark plug is faulty - Change spark plug as required.
Fuel filter is plugged - Fuel filter needs to be replaced.
Brake pedal not pushed down - Push the brake pedal down.
Carburetor malfunction - Check and repair as required.
Low engine compression - Inspect cylinder block and change defective components.
Incorrectly adjusted or damaged throttle cable - Adjust correctly or change the cable.
| Engine runs intermittently |
Cooling fins are clogged - Need to wash or clean.
Ignition system problems - Check ignition and replace faulty components.
Choke cable is stuck or defective - Change or clean the cable.
Air filter element is plugged - Replace or service air filter.
Clogged or damaged fuel pump - Service or change fuel pump.
| Engine starts and then stalls |
Spark plug is damaged - Install new spark plug.
Carburetor is clogged or faulty - Repair or clean carburetor.
Ignition coil is faulty - Change ignition coil as required.
Valve springs are loose or broken - New valve springs need to be installed.
Stuck valves - Valves must be cleaned.
| Engine keeps overheating |
Low engine oil level - Fill the crankcase with engine oil.
Engine is running overloaded - Load reducing required.
Air intake grill is clogged - Need to clean or wash.
Carburetor mixture is too lean - Make the correct settings.
Wrong ignition timing - Ignition timing needs to be set properly.
Incorrect valve setting - Adjust valves correctly.
| Engine noise or knocking |
Stale gasoline - Change fuel.
Engine is overloaded - Load reducing is recommended.
Engine oil insufficient - Need to add engine oil.
Incorrectly set low idle speed - Correct idle settings.
Fuel pump is defective or dirty - Check fuel pump and change if required.
Worn main bearings or crankshaft - Repair or replace defective parts.
Excessive valve clearance - Adjust valve clearance according to specifications.
Worn piston rings or cylinder bore - Replace defective parts.
| Low engine power |
Carburetor is clogged or incorrectly adjusted - Clean or properly adjust carburetor.
Air filter element is plugged - Change or clean air filter.
Fuel pump is dirty or defective - Clean or change fuel pump.
Ignition system problems - Check ignition and replace faulty components.
Blown cylinder head gasket - Install new head gasket.
Stuck or burned valves - Change or service valves.
Damaged or worn push rod - Replace push rod.
Cylinder block parts are damaged - Replace defective components as required.
Dirty oil filter element (if equipped) - Clean or replace oil filter.
| High fuel consumption |
Choke did not open fully - Change or adjust choke cable.
Carburetor main jet is improperly adjusted - Adjust it properly.
Loose or faulty spark plug - Re-tighten or replace spark plug.
Valves are stuck, worn, or burned - Replace or service valves.
Piston, sleeve, or rings are damaged - Change faulty parts.
Valve clearance is improper - Adjustment procedure required.
| Excessive oil consumption |
Seals or gaskets are wearing excessively - Change worn parts according to specifications.
Valve stems and guides are worn - Install new valves.
Piston rings are stuck or worn - Replace piston rings.
Cylinder liner or piston is worn - Check piston and liner, change as required.
Clogged breather hose or pipe - Change or service.
____________________________________________________________________________________