____________________________________________________________________________________
| Home / Small Engines / Honda Engines / Honda G100 |
Honda G100 Troubleshooting
| Engine Model: Honda G100 |
| Engine Type: 4-cycle 1-cylinder air-cooled gasoline engine |
| Displacement (K1/K2): 5.1 cu.in (83 cc) / 6 cu.in (98 cc) |
| Engine Power (K1/K2): 2.2 Hp (1.6 kW) / 2.5 Hp (1.9 kW) |
| Carburetor Type: Horizontal, butterfly valve |
____________________________________________________________________________________
| Engine starts hard or will not start |
Gas tank is empty - Fill gasoline up.
Wrong fuel grade - Use correct gasoline grade.
Air or water in fuel system - Remove water or air from fuel system.
Defective spark plug wire connection - Check the spark plug wire connection, repair or replace.
Defective spark plug - Spark plug need to be replaced.
Plugged fuel filter - Fuel filter needs changing.
Safety contact for brake pedal defective - Install new part.
Carburetor settings incorrect - Adjusting as required.
Bad compression - Check and change damaged parts.
Throttle cable is adjusted incorrectly or damaged - Adjust correctly or replace the cable.
| Engine runs roughly |
Plugged cooling fins - Clean and wash as required.
Ignition system is defective - Test ignition and replace failed parts.
Stuck or defective throttle cable - Replace or clean the cable.
Clogged air filter - Replace or clean air filter.
Fuel pump is damaged or dirty - Check fuel pump and change if required.
| Engine starts and stops suddenly |
Damaged spark plug - Replace spark plug.
Carburetor is dirty or defective - Clean or replace carburetor.
Ignition coil is not working - Ignition coil must be replaced.
Valve springs are worn or loose - Replace valve springs.
Valves sticking - Valves need to be cleaned.
| Engine is overheated |
Not enough engine oil - Fill up the oil to required level.
Engine is under excessive load - Load reducing is recommended.
Cooling fins are blocked - Wash or clean as required.
Carburetor is running lean - Set the carburetor properly.
Ignition timing is improper - Ignition timing needs to be adjusted correctly.
Valve setting is improper - Adjust valves as required.
| Engine knocking or noise |
Low octane fuel - Use correct fuel.
Engine overload - Reduce engine load.
Lack of engine oil - Checking oil level and add if necessary.
Wrong adjustment of low idle speed - Adjust idle speed.
Fuel pump is damaged or dirty - Clean or change fuel pump.
Main bearings or crankshaft failure - Change or repair worn components.
Valve clearance is wrong - Adjust to proper valve clearance.
Cylinder bore or piston rings are worn - Replace faulty parts.
| Engine power is too low |
Dirty or incorrectly adjusted carburetor - Clean or correctly adjust carburetor.
Dirty air filter element - Change or service air filter.
Dirty or damaged fuel pump - Check fuel pump and replace if necessary.
Defective ignition - Inspect ignition system and change failed components.
Cylinder head gasket is worn - Replace the gasket as required.
Burned or stuck valves - Service or change valves.
Bent or worn push rod - Change push rod.
Cylinder block components are faulty - Change defective components.
Oil filter is blocked (if equipped) - Service or change oil filter.
| Engine uses too much fuel |
Choke opening is not full - Replace or adjust choke cable.
Improper carburetor main jet adjustment - Adjust the carburetor main jet correctly.
Spark plug is loose or faulty - Tighten or replace spark plug.
Valves are stuck, burned, or worn - Replace or clean valves.
Sleeve, rings, or piston are damaged - Replace defective components as required.
Valve clearance is not correct - Adjust valve clearance according to specifications.
| High oil consumption |
Worn gaskets or seals - Replace worn parts to avoid leaks.
Valve guides and stems are worn - Valves must be replaced.
Piston rings are seized or worn - Install new piston rings.
Piston or cylinder liner is worn - Inspect piston and liner, change as required.
Breather hose or pipe is clogged - Replace or service.
____________________________________________________________________________________